House Battery Workover

House Battery Compartment

One of the really bad things about a bus or a large Recreational Vech. (RV) are the batteries it takes to run one of these monsters of the highway.  We are battery poor.  Eagles take 3 starter batteries, 8 House batteries, and one battery for the generator.  We just replaced the starter batteries and now because of age, we are replacing the house batteries, all eight of them.  This is no simple chore, and it is not cheap, around $1100.00 for the batteries alone.  The old batteries were WallyWorld Golf Cart (6 years old) and the replacements are Interstate, made in St. Charles Missouri, USA. First order of the day is to get them out of the compartment, they weigh about 160lbs each and lifting them straight up and then out is no easy task.  Some buses have them on a slide out tray but we do not have that luxury.  After removal of the batteries, then it is time to work all the connectors.  You take them to the grinder and do a number on them to remove all evidence of corrosion. Word to the wise.  It is a good idea to make a working diagram of the position of all the cables when you disconnect or at best, take a shot of them with a camera.  It will be a LOT BETTER DEAL later on when you go to re-hook everything up and you cannot remember which way all the cables connected and where all of them went to produce power to the coach.

Next come the new batteries … one at a time.

All eight in place, and re-connected.

Now the real fun begins.  Cleaning up and detailing out the entire compartment.  Which means a lot of masking tape, a lot of scraping and cleaning and then repainting all the surfaces.

Masking and Paint Prep

Polish and bright work

One improvement was a case for the battery maintainers.  And more illumination in the compartment with LED work lights.  The next thing to go in were two utility work lights and a battery maintainer station and its own light set up.

Battery Maintainers and Light Setup

I also felt the need to add a heater box and do something with the back wall which looked awful plain and just downright ugly.  So I fabricated some wood trim and made some improvements in that area at the same time.  In the winter time I close off the compartment and run an electric heater to keep batteries warm and to ward off freezing.  So the back wall got a covering and battery box too.

The following three shots are the bay at about 90% completed.  All that remains are a few odd’s and ends, and it will be a wrap.  This is the final bay restoration on the bus, they have all been reworked and completely refurbished, this is also the last project for the year.

Back wall in place, heater in heater box, almost finished.

Most everything in place … down to detailing it out and wrapping it up.

Comments section is open if you want to leave a reply.



Prevost Community Home Page

Bucket List Rework

I.D. Theft Is Real … Be Careful

At the root of every grey hair, there is a dead brain cell.  Someone had to remind me, so I’m reminding you, too.   Don’t laugh…. It is all true!  Perks of reaching 50 or being over 60 and heading towards 70 or beyond.  Here are some tips for you when the world gets to be the best of thee, when life don’t come across so easily.  Twenty reasons why it is okay to get older.

1. Kidnappers are not very interested in you.

2. In a hostage situation, you are most likely to be released first. 

3. No one expects you to run … anywhere.

4. People call at 9 PM (or 9 AM) and ask,  did I wake you?

5. People no longer view you as a hypochondriac.

6. There is nothing left to learn the hard way.

7. Things you buy now … Won’t wear out.

8. You can eat supper at 4 PM.

9. You can live without sex … But not your glasses.

10. You get into heated arguments about pension plans.

11. You no longer think of speed limits as a challenge.

12. You quit trying to hold your stomach in no matter who walks into the room. 

13. You sing along with elevator music and you know ALL the words to the songs.

14. Your eyes won’t get much worse.

15. Your investment in health insurance is finally beginning to pay off. 

16. Your joints are more accurate meteorologists and can predict the weather better than the national weather service.

17. Your secrets are safe with your friends because they can’t remember them either.

18. Your supply of brain cells is finally down to a manageable size. 

19.  You are glad you have a DVR now you can tape Jay Leno and David Letterman and sleep.

20.You can’t remember where you saw this list, but you are sure glad it was in big print.

You are not over the hill … but you can damn sure see the top of it.